English

应用科学学报 >

2026 , Vol. 44 >Issue 3: 345 - 357

DOI: https://doi.org/10.3969/j.issn.0255-8297.2026.03.001

先进通信

利用压缩感知减缓AFM光纤探针磨损

  • 叶帅 ,
  • 商娅娜 ,
  • 陈娜 ,
  • 刘书朋 ,
  • 刘勇
展开
  • 1. 上海大学特种光纤与光接入网重点实验室, 上海 200444;
    2. 上海大学特种光纤与先进通信国际合作联合实验室, 上海 200444

收稿日期: 2025-03-27

  网络出版日期: 2026-06-23

基金资助

国家自然科学基金(No.62175142)

收起

Compressed Sensing-Based Approach for Reducing Wear in AFM Fiber Probes

  • YE Shuai ,
  • SHANG Yana ,
  • CHEN Na ,
  • LIU Shupeng ,
  • LIU Yong
Expand
  • 1. Key Laboratory of Specialty Fiber Optics and Optical Access Networks, Shanghai University, Shanghai 200444, China;
    2. Joint International Research Laboratory of Specialty Fiber Optics and Advanced Communication, Shanghai University, Shanghai 200444, China

Received date: 2025-03-27

  Online published: 2026-06-23

Fold

摘要

针对原子力显微镜（atomic force microscope,AFM）光纤探针扫描成像中针尖磨损的问题，提出一种基于压缩感知（compressed sensing,CS）的欠采样扫描方法，减少光纤探针与样品的接触次数，有效延长探针的使用寿命。利用CS算法重构得到完整的AFM图像，并通过引入卷积神经网络（convolutional neural network,CNN）优化CS重构图像的质量，解决了因欠采样导致的图像质量下降问题，在减少光纤探针磨损的同时保持了高质量的成像。实验中，当扫描频率为0.3 Hz，扫描点数由200×200降低至100×100时，针尖磨损量由78nm降低至13 nm，成像时间缩短为原来的1/4，通过卷积神经网络优化后，AFM图像的峰值信噪比（peak signal-to-noise ratio,PSNR）和结构相似性（structural similarity,SSIM）分别为30.12 dB和0.96，实现了光纤探针低磨损、快速、高质量的AFM成像。

关键词： 原子力显微镜; 光纤探针; 针尖磨损; 压缩感知; 卷积神经网络

本文引用格式

叶帅 , 商娅娜 , 陈娜 , 刘书朋 , 刘勇 . 利用压缩感知减缓AFM光纤探针磨损[J]. 应用科学学报, 2026 , 44(3) : 345 -357 . DOI: 10.3969/j.issn.0255-8297.2026.03.001

Abstract

To address the issue of tip wear in atomic force microscope(AFM) fiber probe scanning imaging, an undersampling scanning method based on compressed sensing(CS)was proposed, which reduced the number of contacts between the fiber probe and the sample and effectively prolonged the probe lifetime. Complete AFM images were reconstructed using the CS algorithm. A convolutional neural network(CNN) was introduced to optimize the quality of CS-reconstructed images and mitigate the degradation of image quality caused by undersampling. Fiber probe wear was therefore reduced while maintaining high-quality imaging. In the experiments, when the scanning frequency was 0.3 Hz and the number of scanning points was reduced from 200 × 200 to 100 × 100, the tip wear was reduced from 78 nm to 13 nm, and the imaging time was reduced to one quarter of the original imaging time. After optimization using the CNN, the AFM images had a peak signal-to-noise ratio(PSNR) of 30.12 dB and a structural similarity(SSIM) of 0.96. The results demonstrate that low-wear, fast, and high-quality AFM imaging with fiber probes can be achieved.

Key words： atomic force microscope; fiber probe; tip wear; compressed sensing; convolutional neural network(CNN)

参考文献

[1] Binnig G, Quate C F, Gerber C. Atomic force microscope [J]. Physical Review Letters, 1986, 56(9): 930-933.
[2] Tersoff J, Hamann D R. Theory and application for the scanning tunneling microscope [J]. Physical Review Letters, 1983, 50(25): 1998-2001.
[3] Ando T, Uchihashi T, Kodera N, et al. High-speed atomic force microscopy for observing dynamic biomolecular processes [J]. Journal of Molecular Recognition, 2007, 20(6): 448-458.
[4] Jagtap R N, Ambre A H. Overview literature on atomic force microscopy (AFM): basics and its important applications for polymer characterization [J]. Indian Journal of Engineering and Materials Sciences, 2006, 13(4): 368-384.
[5] Liu Z M, Chen N, Li S Y, et al. Modeling and calibration of micro/nano FBG temperature probe for scanning probe microscopy [J]. Optics Express, 2023, 31(12): 19453-19462.
[6] 李韶颖, 陈娜, 刘真民, 等. 基于近场光纤探针的活细胞无损测温方法研究[J]. 中国激光, 2022, 49(3): 0307002. Li S Y, Chen N, Liu Z M, et al. Nondestructive temperature measurement method for living cells based on near-field optical fiber probe [J]. Chinese Journal of Lasers, 2022, 49(3): 0307002. (in Chinese)
[7] Hillman C W J, Brocklesby W S, Monro T M, et al. Structural and optical characterisation of holey fibres using scanning probe microscopy [J]. Electronics Letters, 2001, 37(21): 1283-1284.
[8] 马丽心, 郑纯, 李丹婷, 等. 激光复合AFM探针捕获纳米微粒的作用力分析[J]. 激光与光电子学进展, 2015, 52(7): 070601. Ma L X, Zheng C, Li D T, et al. Analysis of force to capture nanoparticles by composite laser AFM probe [J]. Laser & Optoelectronics Progress, 2015, 52(7): 070601. (in Chinese)
[9] Liu J J, Notbohm J K, Carpick R W, et al. Method for characterizing nanoscale wear of atomic force microscope tips [J]. ACS Nano, 2010, 4(7): 3763-3772.
[10] He Y, Zhang L C, Cui J P, et al. Blunting and wear of AFM tips during dynamic lithography [J]. Wear, 2023, 522: 204694.
[11] Yu Z Y, Huang M Y, Zhang X R. Substrate deformability and applied normal force are coupled to change nanoscale friction [J]. Nanoscale advances, 2024, 6(19): 4922-4931.
[12] Killgore J P, Geiss R H, Hurley D C. Continuous measurement of atomic force microscope tip wear by contact resonance force microscopy [J]. Small, 2011, 7(8): 1018-1022.
[13] Guo L Q, Wang R, Xu H M, et al. Wear-resistance comparison of carbon nanotubes and conventional silicon-probes for atomic force microscopy [J]. Wear, 2005, 258(11/12): 1836-1839.
[14] Tao Z, Bhushan B. Surface modification of AFM silicon probes for adhesion and wear reduction [J]. Tribology Letters, 2006, 21(1): 1-16.
[15] Chung K H, Lee Y H, Kim H J, et al. Fundamental investigation of the wear progression of silicon atomic force microscope probes [J]. Tribology Letters, 2013, 52(2): 315-325.
[16] Volokitin A I. Casimir friction force between a SiO2 probe and a graphene-coated SiO2 substrate [J]. JETP Letters, 2016, 104(7): 504-506.
[17] 唐莹, 曹丛, 张健, 等. AFM设定值对测量准确度和探针寿命的影响[J]. 计量学报, 2019, 40(6): 17-22. Tang Y, Cao C, Zhang J, et al. The effects of different setpoint to measuring accuracy and service life of a probe on AFM [J]. Acta Metrologica Sinica, 2019, 40(6): 17-22. (in Chinese)
[18] 柯丁宁, 况婷, 宋琳琳, 等. 基于超平表面的原子力显微镜探针磨损研究[J]. 分析测试学报, 2019, 38(7): 870-873. Ke D N, Kuang T, Song L L, et al. Study on tip wear of atomic force microscope using ultra-flat surface [J]. Journal of Instrumental Analysis, 2019, 38(7): 870-873. (in Chinese)
[19] Xu M, Zhou Z Q, Ahbe T, et al. Using a tip characterizer to investigate microprobe silicon tip geometry variation in roughness measurements [J]. Sensors, 2022, 22(3): 1298.
[20] Huang S, Tian Y L, Wang T. Experimental investigation of tip wear of AFM monocrystalline silicon probes [J]. Sensors, 2023, 23(8): 4084.
[21] Xu K, Leng H W. Quantitative wear evaluation of tips based on sharp structures [J]. Beilstein Journal of Nanotechnology, 2024, 15: 230-241.
[22] Xie F J, Zhong M, Li X B, et al. Study on the microscopic removal mechanism of interconnect metal Co using AFM with Si, SiO2, and diamond probes [J]. Tribology International, 2025, 205: 110553.
[23] Donoho D L. Compressed sensing [J]. IEEE Transactions on Information Theory, 2006, 52(4): 1289-1306.
[24] Maxwell B D, Andersson S B. A compressed sensing measurement matrix for atomic force microscopy [C]//American Control Conference, 2014: 1631-1636.
[25] Tosic I, Frossard P. Dictionary learning [J]. IEEE Signal Processing Magazine, 2011, 28(2): 27-38.
[26] Pati Y C, Rezaiifar R, Krishnaprasad P. Orthogonal matching pursuit: recursive function approximation with applications to wavelet decomposition [C]//27th Asilomar Conference on Signals, Systems and Computers, 1993: 40-44.
[27] Zhang J, Zhao D B, Gao W. Group-based sparse representation for image restoration [J]. IEEE Transactions on Image Processing, 2014, 23(8): 3336-3351.
[28] Li C B, Yin W T, Jiang H, et al. An efficient augmented Lagrangian method with applications to total variation minimization [J]. Computational Optimization and Applications, 2013, 56(3): 507-530.
[29] Han G Q, Wu T, Lv L Y, et al. Super-resolution AFM imaging based on enhanced convolutional neural network [J]. Nano, 2021, 16(12): 2150147.
[30] Zhang J, Ghanem B. ISTA-Net: interpretable optimization-inspired deep network for image compressive sensing [C]//31st IEEE/CVF Conference on Computer Vision and Pattern Recognition, 2018: 1828-1837.
[31] Lowe D G. Distinctive image features from scale-invariant keypoints [J]. International Journal of Computer Vision, 2004, 60(2): 91-110.
[32] Wang Z, Bovik A C, Sheikh H R, et al. Image quality assessment: from error visibility to structural similarity [J]. IEEE Transactions on Image Processing, 2004, 13(4): 600-612.
Options
文章导航

/

〈 〉